產品名稱：AW40系列SMC分離器產品參數
更新時間：2023-05-07
產品報價：
產品特點：AW40系列SMC分離器產品參數日本SMC分離器，SMC前置過濾油霧分離器AMH150C-02D-T額定流量為200L/min，接管口徑1/8，重量0.38kg。使用流體壓縮空氣。
AW40系列SMC分離器產品參數的詳細資料：
SMC微霧分離器的微霧分離器效果較好，適用于大型制冷系統，其結構如圖7-3所示。壓縮機的排氣經油分離器進氣管沿切線方向進入筒內，隨即沿螺旋導向葉片高速旋轉并自上而下流動。借離心力的作用將排氣中密度較大的油滴拋在筒壁上分離出來，沿壁流下，沉積在筒底部。蒸氣經筒體中心的出氣管內多孔板引出。筒側裝有浮球閥，當油面上升到上限位時，潤滑油通過浮球閥打開閥芯，自動向壓縮機曲軸箱或集油器排油。有的在油分離器外部還設有冷卻水套，使混合汽體在其中又受到冷卻水的冷卻并通過降低流速和改變流向的作用，進一步得到分離。
日本進口SMC微霧分離器的應用也逐漸增多。結構不同，三相分離器的控制方法也不同。兩種典型分離器的控制原理如下：
（1）油氣水混合物進入分離器后，進口分流器把混合物大致分成汽液兩相，液相進入集液部分。集液部分有足夠的體積使自由水沉降至底部形成水層，其上是原油和含有較小水滴的乳狀油層。原油和乳狀油從擋板上面溢出。擋板下游的油面由液面控制器操縱出油閥控制于恒定的高度。水從擋板上游的出水口排出，油水界面控制器操縱排水閥的開度，使油水界面保持在規定的高度。分離器的壓力由設在天然氣管線上的閥門控制。油微粒經過濾材的擴散作用，直接被濾材攔截以及慣性碰撞凝聚等機理，使壓縮空氣中的懸浮油微粒很快凝聚成大油滴，在重力作用下油集聚在油分芯底部，通過底部凹處回油管進口返回機頭潤滑油系統，從而使壓縮機排出更加純凈無油的壓縮空氣。壓縮空氣中的固體粒子經過油分芯時滯留在過濾層中，這就導致了油分芯壓差（阻力）不斷增加。隨著油分芯使用時間增長，當油分芯壓差達到0.08到0.1Mpa時，濾芯必須更換，否則增加壓縮機運行成本（耗電）。
SMC氣缸型號：
CHDKGB50-10
CHDKGB50-100
CHDKGB50-15
CHDKGB50-15M
CHDKGB50-20
CHDKGB50-25
CHDKGB50-35
CHDKGB50-40
CHDKGB50-50
CHDKGB50-75
CHDKGB5050MXC62
CHDKGB63-100
CHDKGB63-25
CHDKGB63-30
CHDKGB63-35
CHDKGB63-35M
CHDKGB63-40
CHDKGB63-50
CHDKGB63-75
CHDKGB63-80M
CHDKGB80-100
CHDKGB80-100M
CHDKGB80-15M
CHDKGB80-150
CHDKGB80-25
CHDKGB80-50
CHDKGB80-75
CKZ3T50-90T
CKZT50-A015CB
CKZ3T63-105T
CKZT63-A045CS
CKZ1N50-135LT
CKZ1N50-135RT
CKZ2N50-120RT
CKZ2N50-135RT
CKZ3N50-45DT
CKZ3N50-90DP
CKZ3N63-45DP
CKZ3N63-90DT
CKZ-50A011
CKZN50-135LN
CKZN50-135RN
CKZT40-135T
CKZT40-30T
CKZT40-45T
CKZT40-60T
CKZT40-A015CS
CKZT40-A015LS
CKZT40-A015RS
CKZT40-A045CS
CKZT63-120T
CKZT63-A045CS
CKZT63-A045LS
CKZT63-A045RS
CKZT63TN-120T
CKA80-KRF0027-75Y-P5DWZ
CKA-K75
CKA-Y04
CKA-YA04
CKB40-17-102B
CKB40-18-207A
CKB40-18-207B
CKB-Y04
CKCV32-135B-RH
CKG1A40-100
CKG1A40-100Y
CKG1A40-100YA
CKG1A40-125
CKG1A40-125Y
CKG1A40-125YA
CKG1A40-50
CKG1A40-50Y
CKG1A40-50YA
CKG1A40-50YA-P
CKG1A40-50Y-P
CKG1A40-50YZ
CKG1A40-75Y
CKG1A40-75YA
CKG1A40-75YA-P
CKG1A40-75Y-P
CKG1A40-75Y-P5DWL
CKG1A40-75YZ
CKG1A50-100
CKG1A50-100Y
CKG1A50-100YA
CKG1A50-100YABD-L
CKG1A50-100YA-P
CKG1A50-100YBD-L
CKG1A50-100Y-P
CKG1A50-125-X276A
CKG1A50-125Y
CKG1A50-125YA
CKG1A50-125YABD-L
CKG1A50-125YAD
CKG1A50-125YA-P
CKG1A50-125YBD-L
CKG1A50-125YD
CKG1A50-125Y-P
CKG1A50-150
CKG1A50-150Y
CKG1A50-150YA
CKG1A50-150YABD-L
CKG1A50-150YBD-L
CKG1A50-40YA
CKG1A50-50
CKG1A50-50Y
CKG1A50-50YA
CKG1A50-50YA-X276A
CKG1A50-50YA-X276B
CKG1A50-50YABDL
CKG1A50-50YA-P
CKG1A50-50YBDL
CKG1A50-50Y-P
CKG1A50-50Y-X276A
CKG1A50-50Y-X276B
CKG1A50-75
CKG1A50-75Y
CKG1A50-75YA
CKG1A50-75YABDL
CKG1A50-75YA-P
CKG1A50-75YA-X738
CKG1A50-75YBDL
CKG1A50-75Y-P
CKG1A50-75Y-X1515
CKG1A50-75Y-X738
CKG1A50-75YZ
CKG1A63-100
CKG1A63-100-P
CKG1A63-100Y
CKG1A63-100YA
CKG1A63-100YABD-L
CKG1A63-100YA-P
CKG1A63-100YBD-L
CKG1A63-100Y-P
CKG1A63-125
CKG1A63-125B
CKG1A63-125Y
CKG1A63-125YA
CKG1A63-125YABD-L
CKG1A63-125YAD
CKG1A63-125YA-P
CKG1A63-125YBD-L
CKG1A63-125YD
CKG1A63-125Y-P
CKG1A63-150Y
CKG1A63-150YA
CKG1A63-150YABD-L
CKG1A63-150YA-L
CKG1A63-150YA-P
CKG1A63-150YBD-L
CKG1A63-150Y-L
CKG1A63-150Y-P
CKG1A63-150Z
CKG1A63-200Y
CKG1A63-200Y-P
CKG1A63-30
CKG1A63-300Y-P
CKG1A63-50
CKG1A63-50Y
CKG1A63-50YA
CKG1A63-50YABDL
CKG1A63-50YA-P
CKG1A63-50YBDL
CKG1A63-50Y-P
CKG1A63-75
CKG1A63-75Y
CKG1A63-75YA
CKG1A63-75YABDL
CKG1A63-75YA-P
CKG1A63-75YBDL
CKG1A63-75Y-P
CKG1A63-75Y-P
CKG1A63-KRF0028-125YBDL
CKG1A63-KRF0028-75YBD
CKG1B40-50
CKG1B40-50Y
CKG1B40-50YA
CKG1B50-100
CKG1B50-100I
CKG1B50-100Y
CKG1B50-100YA
CKG1B50-100YA-X276A
CKG1B50-100YAL
CKG1B50-100YL
CKG1B50-100Y-X276A
CKG1B50-125Y
CKG1B50-125YA
CKG1B50-125YAL
CKG1B50-125YL
CKG1B50-150
CKG1B50-150Y
CKG1B50-150YA
CKG1B50-25Y
CKG1B50-25YA
CKG1B50-50
CKG1B50-50-P
CKG1B50-50-X1515
CKG1B50-50Y
CKG1B50-50YA
CKG1B50-75Y
CKG1B50-75YA
CKG1B50-75YA-X276A
CKG1B50-75YAL
CKG1B50-75YL
CKG1B50-75Y-X276A
CKG1B63-100
CKG1B63-100Y
CKG1B63-100YA
CKG1B63-100YA-P
CKG1B63-100YZ
CKG1B63-125
CKG1B63-125I
CKG1B63-125Y
CKG1B63-125YA
CKG1B63-150Y
CKG1B63-150YA
CKG1B63-50
CKG1B63-50Y
CKG1B63-50YA
CKG1B63-50Z
CKG1B63-75
CKG1B63-75Y
CKG1B63-75YA
CKG1P63-150YA-P
CKG1P63-150Y-P
CKG40-R050
CKG40-R075
CKG40-R100
CKGA100-125Y
CKGA100-150YL
CKGA100-150Y-P
CKGA32-100Y-X1046
CKGA32-125Y-X1046
CKGA32-75Y-X1046
CKGA32-B6859-100Y
CKGA32-B6859-125Y
CKGA32-B6859-150Y
CKGA32-B6859-50Y
CKGA32-B6859-75Y
CKGA80-100Y
CKGA80-125Y
CKGA80-150YL
CKGA80-50Y
CKP1A63-100Y
CKP1A63-100YA
CKP1A63-125
CKP1A63-125Y
CKP1A63-125YA
CKP1A63-125YA-P74
CKP1A63-125Y-P74
CKP1A63-150
CKP1A63-150Y-P74-85G-X906
CKP1A63-150Y
CKP1A63-150YA
CKP1A63-200Y
CKP1A63-200YA
CKP1A63-50Y-P74-85G-X1442
CKP1A63-50Y
CKP1A63-50YA
CKP1A63-75Y
CKP1A63-75YA
CKP1A63-75YA-P74
CKP1A63-75Y-P74
CKP1A63-75Y-P74-85G-X404
CKP1A63-B5052-50Y
CKP1A63-S0971-50
CKP1A63-S0971-75
CKP1AM63-200Y
CKPA80-150Y
CKQ40-25-DCH244DH
CKQ40-25-DCH245DH
CKQ40-25-DCH248DH
CKQ40-25-DCH249DH
CKQ40-P6136-25
CKQ40-P6138-25
CKQ40-P6140-25
CKQ40-P6142-25
CKQ40-P9616-25
CKQ40-W0377-25
CKQ40-W0378-25
CKQ40-W3950-25
CKQ40-W3951-25
CKQ50-15-DCJ9682J
CKQ50-DCG2437GA15
CKQ50-DCG2438GA15
CKQ50-DCG5907GL12
CKQ50-DCG5918GCA15
CKQ50-DCG7225G-16
CKQ50-DCG7226G-16
CKQ50-DCG5918GCA15
CKQ50-P5743-30
CKQ50-P7118-30
CKQ50-W3247-15
CKQ50-W3247A15
CKQ50-W3247B15
CKQ50-W8040A15
CKQ50-W8041A15
CKQGDB50-199RALS
CKQN50-25-155WA
CKQN50-25-158WA
CKQSC50-125RC
CKQSF50-125RDS
CHDKGB80150XB11
CHDMB20-Z0860
CHDMB20-200
CHDMB20-25
CHDMB20-40
CHDMB20-75
CHDMB20Z0860155
CHDMB25-50
CHDMB25-75
CHDMB32-100
CHDMB32-80
CHDMB40-250
CHDMB40K
CHDMC20-75
CHDMC32-80
CHDMC40-25
CHDMF20-40
CHDMF25-40
CHDMF32-350
CHDMF32-50
CHDMF32K
CHDMG20-205
CHDMG32-75
CHDML20-400
CHDML20-50
CHDML25-200
CHDQB100-100
CHDQB100-100D
CHDQB100-25D
CHDQB100-50D
CHDQB100-75D
CHDQB100R184910
CHDQB20-0128624
上海維特銳實業發展有限公司現貨供應德國力士樂電磁閥系列產品，如需詳細了解請點擊：日本SMC
| 如果你對AW40系列SMC分離器產品參數感興趣，想了解更詳細的產品信息，填寫下表直接與廠家聯系： |
上一篇：MXS6系列SMC滑臺氣缸
下一篇：AW40系列SMC減壓閥